Tesla Model S: Air Conditioning System Precautions
Tesla Model S (2012-2026) Service Manual / Best Practice / Air Conditioning System Precautions
- Air Conditioning System Precautions - General
- Refrigerant evacuation and recharging
- Debris or moisture in the A/C system
READ NEXT:
Air Conditioning System Precautions - General
The air conditioning system contains fluids and components which could
be potentially hazardous to the technician or the environment if not
serviced and handled correctly. The following guidelin
Refrigerant evacuation and recharging
The HVAC and battery coolant circuits are sealed to prevent the
discharge of refrigerant. The refrigerant must be recovered before any
removal of system components using the recommended equipmen
Debris or moisture in the A/C system
Internally or externally damaged components can cause debris and
moisture to enter the A/C system. Perform the following procedures if
debris or excessive moisture ingress is suspected.
Cau
SEE MORE:
Vent - Motorized - Front Fascia - LH (Remove and Replace)
Removal
If the vehicle is equipped with 1st generation front fascia
applique, remove front fascia applique (refer to procedure) .
Remove ankle catcher foam, if equipped.
Disconnect motorized vent harness connector.
Gearbox Fluid - Small Rear Drive Unit (Remove and Replace)
Warning: If the vehicle has air suspension, activate "Jack"
mode on the touchscreen before raising and supporting the vehicle.
Drain & Refill
Position the vehicle in preparation for raising it, but do not
raise it at this time.
Air suspension vehicles only: Depressurize th
© 2019-2026 Copyright www.tesms.org
