Tesla Model S: A/C Refrigerant Recovery and Recharge (Remove and Replace)
Tesla Model S (2012-2026) Service Manual / Thermal Management / A/C Refrigerant Recovery and Recharge (Remove and Replace)
READ NEXT:
Set Up HVAC Machine
Warning: Servicing must only be performed by personnel
familiar with both vehicle systems and the charging and testing
equipment. Always read and understand the HVAC machine operator's
man
Recover Refrigerant and Verify Charge
Note: Before beginning this section,
complete the "Set Up HVAC Machine" section.
Connect a laptop with Toolbox to the vehicle.
Remove the rear underhood apron (refer to procedure).
AC Refrigerant Leak Detection
Recover refrigerant from the vehicle (refer to procedure), see section "Recover
Refrigerant and Verify Charge").
Remove the underhood storage unit(refer to procedure).
Release the bolt that se
SEE MORE:
Headlining (Remove and Install)
Note: This procedure does not remove headlining from
vehicle, the headlining remains captive within the body.
Removal
Remove LH 'A' post trim (refer to procedure)
Remove RH 'A' post trim.
Release the LH upper 'B' post trim (refer to procedure).
Release the RH upper
Actuator - Mode (Remove and Replace)
Removal
Remove IP carrier (refer to procedure)
Disconnect duct temperature sensor harness connector.
Remove screw securing duct to HVAC assembly and position duct
aside (torque 1 Nm).
Disconnect actuator harness
© 2019-2026 Copyright www.tesms.org
